Construction points
1. Clean the concrete surface with acetone.
2, the surface to be bonded to repair the formation of a leak, the phenomenon of water to stop, guide water treatment.
3. When the bottom layer is glued and coated, the thickness of the coating shall be determined according to the specific conditions of the air temperature and the construction bonding structure, especially if the winter temperature is below 5°C. If necessary, the necessary temperature raising measures shall be taken.
4, when bonding carbon fiber sheet, first cut the required size according to technical requirements, generally two meters is appropriate.
5, configuration glue, generally available time (about 30min) the amount required for construction is limited.
6. Put the glue of Group A and Group B into a clean container according to the ratio of Group A: Group B = 3:1, mix well, and use a smooth roller to repeatedly roll on the surface of the carbon fiber cloth to the glue in the same direction. Exudate the surface of the fiber cloth to remove air bubbles so that the carbon fiber cloth can fully infiltrate the glue. The overlap area of ​​the carbon fiber sheet must be set 10 cm or more.
7. Multi-layer sticking should be performed on the surface of the upper carbon fiber cloth after the touch is dry, and then paste the next layer of carbon fiber cloth.
8. When it is cured, it should be protected from rain, wind and sand, and prevent hard objects from scratching the bonding surface.
9. The curing time should not be less than 3-7 days. After curing, the surface coating shall be performed according to the requirements.
10, B component prone to discoloration during the long storage process, is normal, does not affect the basic performance and use of the product.
11. In the course of construction, if you accidentally splash on the skin or in your eyes, rinse with plenty of water immediately. In severe cases, you should seek medical advice promptly.
Features
1. Polymer nanomaterial modified epoxy resin, superior performance;
2, anti-impact and hot and humid aging, fully meet the national standard;
3, the site is easy to use, the amount of savings, and fiber cloth fit;
4, green, non-toxic, safe to use.
Performance
Carbon rubber project
Technical indicators
glue
body
Sex
can
Tensile strength (MPa)
≥40
Tensile modulus (MPa)
≥2500
Elongation(%)
≥1.5
Flexural strength (MPa)
≥ 50, and must not be brittle (broken)
Compression strength (MPa)
≥70
stick
Knot
can
force
Steel-steel tensile shear strength (MPa)
≥14
Steel-steel non-uniform tear strength (KN/m)
≥20
Bonding strength with concrete (MPa)
≥2.5, and for concrete cohesive failure
Non-volatile content (solid content) (%)
≥99
Reduced tensile shear strength after 90 days of damp heat aging (%)
≤10
Weight ratio (recommended ratio)
2:1
Mixed density
1.05-1.25g/cm3
Room temperature (25°C) operation time
≥40min
[HANDS FREE READING LIGHT.]No more holding a flashlight by your hand or by your mouth, or wear a headlamp on your head, nodding your head like a robot to adjust the light directions when you are reading or busy in repairing. This flexible neck light helps you just focus on what you are doing without worrying about the light, whenever for reading in bed, repairing, craft, knitting, working and camping etc.
[LOVE TO READ IN BED AT NIGHT WITHOUT DISTURBING YOUR PARTNER?] Our book light is equipped by 2 LED for each arm. 1 LED for flashlight spot mode, another 1 LED for flood wide area light mode. Each arm has an independent switch for 3 brightness levels dimmable. Special lampshade design make it shining the smallest area with enough bright light for reading without disturbing your sound asleep partner.
[Eye Caring & Wider Lighting Area.]No flickering and harmful blue light filter design with advanced LED beads. Reduce eye strain for both kids and adults. 2 infinitely bendable necks allow you to set the best lighting areas you want. Paperbacks can also be used.
[NO MORE WASTING MONEY ON BATTERIES -EVER. ]FEATURES BUILT-IN RECHARGEABLE 700MAH LI-ION BATTERY. It has a life-span of 1000 cycles, equal to 3,000 pcs of AAA batteries, save your money and save the earth. Enjoy your wireless up to 10 HOURS reading without needing charge.Charger not included. Standard micro-USB CABLE included. No headache if the cable lost.
Bedside Reading Lamps,Rechargeable Book Light,Portable Reading Light,Bedside Reading Light
Ningbo Wason Lighting Technology Co.,Ltd , https://www.wasonlights.com